Product ID:AEROSOL SPRAY PAINT, 1246 MARINE BLUE
MSDS Date:03/23/1988
FSC:8010
NIIN:00N023361
MSDS Number: BPYRQ

ZYNOLYTE PRODUCTS INC

2320 E DOMINGUEZ ST
CARSON, CA 90749
US

Emergency Phone: 213-513-0700;800-424-9300(CHEMTREC)

Info Phone: 213-513-0700

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

PIGMENT, BONE RED

CAS: 16013-44-8

DIATOMACEOUS EARTH

CAS: 7631-86-9

OSHA PEL 6 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

METHANE, DICHLORODIFLUORO-; (DICHLORODIFLUOROMETHANE)

CAS: 75-71-8

RTECS: PA8200000

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

1.7

CAS: 108-83-8

RTECS: MJ5775000

OSHA PEL 50 PPM

ACGIH TLV: 25 PPM; 9293

DIPROPYLENE GLYCOL, MONOMETHYL ETHER; (DIPROPYLENE GLYCOL

CAS: 34590-94-8

RTECS: JM1575000

OSHA PEL 100PPM/150STEL, S

ACGIH TLV: 100PPM/150STEL, S

76

CAS: 141-78-6

RTECS: AH5425000

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHYL ALCOHOL; (ETHANOL (MFR CAS NO 152-51-2))

CAS: 64-17-5

RTECS: KQ6300000

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

GILSONITE

CAS: 12002-43-6

NON-HAZARDOUS POLYMER

BLUE PIGMENT; (PHTHALOCYANINE BLUE PIGMENT)

CAS: 147-14-8

POLYESTER PLASTICIZER

ACRYLIC POLYMER

CAS: 25608-63-7

ALUMINUM

CAS: 7429-90-5

RTECS: BD0330000

OSHA PEL 15MG/M3 DUST/5 FUME

ACGIH TLV: 10MG/M3 DUST/5 FUME

CLAY (KAOLIN); (ALUMINUM SILICATE)

CAS: 1332-58-7

RTECS: GF1670500

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 2 MG/M3 TDUST; 9293

76

CAS: 1336-21-6

RTECS: BQ9625000

OSHA PEL 35 PPM STEL

ACGIH TLV: 25 PPM, 35 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SILICON DIOXIDE, AMORPHOUS; (AMORPHOUS SILICA)

CAS: 7631-86-9

OSHA PEL 6 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

10

CAS: 64742-95-6

OSHA PEL 25 PPM (MFR)

ACGIH TLV: 25 PPM (MFR)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INGEST: GI DISTRESS. INHAL:
OVEREXPOSURE MAY CAUSE NOSE AND THROAT IRRIT. MAY CAUSE CNS EFTS
SUCH AS DIZZ, HDCH, NAUS, STAGGERING GAIT, CONFUSION & UNCON.
REPORTS HAVE ASSOCIATED RPTD & PRLNGD OVEREXP TO SOLV W/PERM BRAIN
& NERVOUS SYS DAMAGE. EYE WATERING, HDCH, NAUS, DIZZ, & LOSS OF
COORDINATION ARE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SIGNS THAT SOLV LEVS ARE TOO HIGH.
SKIN/EYE: MAY CAUSE EYE IRRIT OR BURNING OF EYES. RPTD/PRLNGD LIQ
CONTACT MAY CAUSE SKIN IRRIT W/DISCOMFORT AND DERMATITIS. SEE
ORIGINAL MSDS FOR SPECIFIC HAZARDS OF INDIVIDUAL INGREDIENTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGEST: CALL PHYS IMMED AND HAVE NAMES OF INGREDS AVAILABLE.
DO NOT INDUCE VOMITING. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG,
GIVE ARTF RESP, PREFERABLY MOUTH TO MOUTH. IF BRTHG DFCLTY
PERSISTS, OR O CCURS LATER, CONSULT PHYS. EYE: IMMED FLUSH WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES; CALL PHYS. SKIN: WASH WITH
SOAP AND WATER. IF IRRITATION OCCURS CONTACT PHYSICIAN.

Flash Point Method:CC
Flash Point:<20F,<-7C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROT EQUIP
. H*2O MAY BE IN-EFFECTIVE. H*2O FROM FOG NOZ MAY BE USED TO COOL
CLOSED CNTNRS TO PREVENT PRESS BUILD-UP.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. KEEP AT ROOM
TEMPERATURE AS EXPOSURE TO SUNLIGHT OR OTHER HEAT MAY CAUSE CANS TO
BURST, PROPELLING CONTENTS ACROSS AREA.

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT AND BREATHING VAPOR. CONFINE AND REMOVE WITH
INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS & FLAME. DO NOT STORE >120F. DO NOT EXPOS TO
DIRECT SUNLIGHT TO AVOID BURSTING.
Other Precautions:WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING AND
SMOKING. DO NOT SAND, FLAME CUT, BRAZE OR WELD DRY COATING WITHOUT
NIOSH/MSHA APPROVED RESPIRATOR OR APPROPRIATE VENTILATION. DO NOT
PUNCTURE. DO N OT SPRAY NEAR FIRE OR OPEN FLAME.

Respiratory Protection:DO NOT BREATHE VAPORS OR MISTS. WEAR NIOSH/MSHA
APPROVED APPROP, PROPERLY FITTED RESP DURING AND AFTER APPLICATION
UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST LEVELS ARE BELOW
APPLIC LIMITS. FOLLOW RESP MFR'S DIRECTIONS FOR RESP USE.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOL AND PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SOL IN H*2O: MODERATE-APPRECIABLE, DEPENDING ON COLOR.

HCC:V3
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:SUPP DATA
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:92

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE. HAZARDOUS DECOMPOSITION PRODS: CO, CO*2,
SMOKE OXIDES OF HEAVY METALS.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F.
Hazardous Decomposition Products:CO, CO*2, SMOKE, OXIDES OF HEAVY
METALS.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.